Citation: | YANG Qian, YANG Qinghua, CHEN Feng, NIU Bingkun. Experimental Study on Hydraulic Characteristics in Baffle-Drop Shaft During Gas Explosion[J]. Journal of Southwest Jiaotong University, 2023, 58(5): 1026-1036. doi: 10.3969/j.issn.0258-2724.20220163 |
In order to investigate the response relationship between the gas explosion mechanism and parameters such as water depth, inlet pressure, inlet volume, and connected area of dry/wet areas, a 1∶50 scale hydraulic model test system was first conducted to observe the gas explosion jetting process and analyze the variation law of pressure in the shaft. Secondly, a prediction model for the maximum jetting height of the shaft and the critical conditions of the gas explosion were established according to the definition of the gas explosion. Finally, the influences of different variables on the impact load of different baffles in the bottom of the shaft were compared. The results show that the pressure in the baffle-drop shaft fluctuates sharply during a gas explosion. On the one hand, it is caused by the release of high-pressure air mass; on the other hand, high-speed movement of the air-water mixture makes the local pressure in the shaft imbalanced, which contributes to strong fluctuation. The empirical formula established by the multiple linear regression model can effectively predict the maximum jetting height of the baffle-drop shaft. The critical condition established according to the response relationship between the gas explosion intensity and different variables can accurately determine whether a gas explosion occurs. Except for the inlet pressure, submerged state of the baffle, and measured point location, the hydrodynamic load on the baffle in the bottom of the shaft during the gas explosion is also related to the randomness of air-water mixture jetted on the baffle bottom. The maximum hydrodynamic load on the baffle bottom during a gas explosion is more than 10 times as much as the hydrodynamic load on the baffle surface under normal discharge conditions.
[1] |
WRIGHT S J, LEWIS J W, VASCONCELOS J G. Geysering in rapidly filling storm-water tunnels[J]. Journal of Hydraulic Engineering, 2011, 137(1): 112-115. doi: 10.1061/(ASCE)HY.1943-7900.0000245
|
[2] |
POZOS-ESTRADA O, POTHOF I, FUENTES-MARILES O A, et al. Failure of a drainage tunnel caused by an entrapped air pocket[J]. Urban Water Journal, 2015, 12(6): 446-454. doi: 10.1080/1573062X.2015.1041990
|
[3] |
SONG C C S, GUO Q Z, ZHENG Y F. Hydraulic transient modeling of TARP systems[R]. Minneapolis: University of Minnesota, Minneapolis, 1988.
|
[4] |
GUO Q Z, SONG C. Dropshaft hydrodynamics under transient conditions[J]. Journal of Hydraulic Engineering, 1991, 117(8): 1042-1055. doi: 10.1061/(ASCE)0733-9429(1991)117:8(1042)
|
[5] |
LEON A S. Mechanisms that lead to violent geysers in vertical shafts[J]. Journal of Hydraulic Research, 2019, 57(3): 295-306. doi: 10.1080/00221686.2018.1459895
|
[6] |
LEON A S, ELAYEB I S, TANG Y. An experimental study on violent geysers in vertical pipes[J]. Journal of Hydraulic Research, 2019, 57(3): 283-294. doi: 10.1080/00221686.2018.1494052
|
[7] |
VASCONCELOS J G, WRIGHT S J. Geysering generated by large air pockets released through water-filled ventilation shafts[J]. Journal of Hydraulic Engineering, 2011, 137(5): 543-555. doi: 10.1061/(ASCE)HY.1943-7900.0000332
|
[8] |
LEWIS J, WRIGHT S J, VASCONCELOS J, et al. Mechanisms for surges in vertical shafts in stormwater tunnels[J]. Journal of Water Management Modeling, 2011: 41-55.
|
[9] |
VASCONCELOS J G, WRIGHT S J. Investigation of rapid filling of poorly ventilated stormwater storage tunnels[J]. Journal of Hydraulic Research, 2009, 47(5): 547-558. doi: 10.3826/jhr.2009.3390
|
[10] |
SHAO Z Y, YOST S A. Using a multiphase flow numerical model to simulate geysers in stormwater systems[C]//World Environmental and Water Resources Congress 2013. Cincinnati: ASCE, 2013: 1827-1838.
|
[11] |
ZHOU F, HICKS F E, STEFFLER P M. Transient flow in a rapidly filling horizontal pipe containing trapped air[J]. Journal of Hydraulic Engineering, 2002, 128(6): 625-634. doi: 10.1061/(ASCE)0733-9429(2002)128:6(625)
|
[12] |
CHEGINI T, LEON A S. Numerical investigation of field-scale geysers in a vertical shaft[J]. Journal of Hydraulic Research, 2020, 58(3): 503-515. doi: 10.1080/00221686.2019.1625817
|
[13] |
LI X, ZHANG J, ZHU D Z, et al. Modeling geysers triggered by an air pocket migrating with running water in a pipeline[J]. Physics of Fluids, 2023, 35(4): 045126. doi: 10.1063/5.0138342
|
[14] |
安瑞冬,游景皓,廖磊等. 深层隧道排水系统中井隧水力学特性研究[J]. 水利学报,2021,52(12): 1498-1507. doi: 10.13243/j.cnki.slxb.20210090
AN Ruidong, YOU Jinghao, LIAO lei, et al. Study on the hydraulic characteristics of dropshaft and tunnel in the deep tunnel drainage system[J]. Journal of Hydraulic Engineering, 2021, 52(12): 1498-1507. doi: 10.13243/j.cnki.slxb.20210090
|
[15] |
BASHIRI-ATRABI H, HOSODA T. The motion of entrapped air cavities in inclined ducts[J]. Journal of Hydraulic Research, 2015, 53(6): 814-819. doi: 10.1080/00221686.2015.1060272
|
[16] |
HUANG B, WU S Q, ZHU D Z, et al. Experimental study of geysers through a vent pipe connected to flowing sewers[J]. Water Science and Technology: a Journal of the International Association on Water Pollution Research, 2017, 2017(1): 66-76.
|
[17] |
LIU J C, ZHANG S Q, HUANG B, et al. Numerical study on effects of chamber design and multi-inlet on storm geyser[J]. Water Science and Technology: a Journal of the International Association on Water Pollution Research, 2021, 83(6): 1286-1299. doi: 10.2166/wst.2021.061
|
[18] |
DAVIES R M, TAYLOR G. The mechanics of large bubbles rising through extended liquids and through liquids in tubes[J]. Proceedings of the Royal Society A, 1950, 200(1062): 375-390.
|
[19] |
WRIGHT S J, LEWIS J, VASCONCELOS J, et al. Mechanisms for stormwater surges in vertical shafts[J]. Journal of Water Management Modeling, 2007: 109-131.
|
[20] |
YANG Q H, YANG Q. Experimental investigation of hydraulic characteristics and energy dissipation in a baffle-drop shaft[J]. Water Science and Technology: a Journal of the International Association on Water Pollution Research, 2020, 82(8): 1603-1613. doi: 10.2166/wst.2020.441
|
[21] |
刘万海,王翔. 动能定理在物理问题教学中的应用: 以空气阻力上抛运动为例[J]. 绵阳师范学院学报,2020,39(5): 20-23,30.
LIU Wanhai, WANG Xiang. The application of kinetic energy theorem in the teaching of practical physics: an example of up-throw motion in air[J]. Journal of Mianyang Teachers’ College, 2020, 39(5): 20-23,30.
|
[1] | XU Lueqin, XU Yihong, CHEN Liang, JIANG Linsong, ZHOU Jianting. Shear Bearing Capacity of Ultra-High Performance Concrete Keyed Joints Based on Shear-Compression Strength Criterion[J]. Journal of Southwest Jiaotong University, 2025, 60(2): 253-261. doi: 10.3969/j.issn.0258-2724.20230042 |
[2] | WANG Yusuo, TIAN Siming, YANG Junxiang, WANG Mingnian, WANG Wei, LI Chuanbao, ZHAO Zhuang, XIAO Peng. Research on the Calculation Method of Falling Rock Impact Load[J]. Journal of Southwest Jiaotong University. doi: 10.3969/j.issn.0258-2724.20240019 |
[3] | JIANG Yuan, LIU Jinyang, HUI Yi, LIU Rui. Impact of Horizontal Ribs on Aerodynamic Characteristics of High-Rise Buildings[J]. Journal of Southwest Jiaotong University. doi: 10.3969/j.issn.0258-2724.20230584 |
[4] | LUO Xun, YANG Jie, TIAN Hongtao, LIU Dagang, WANG Xiaoyong. Characteristics and Calculation Method of Impact Load in Rockburst Tunnel[J]. Journal of Southwest Jiaotong University, 2024, 59(5): 1095-1103. doi: 10.3969/j.issn.0258-2724.20220373 |
[5] | YIN Zihong, ZENG Yi, WEI Honglin, YIN Zhi, GAO Jingjing. Time-Frequency Characteristics of Vibration Acceleration of High-Speed Railway Subgrade Under Ejection Impact Load[J]. Journal of Southwest Jiaotong University, 2023, 58(1): 219-226. doi: 10.3969/j.issn.0258-2724.20211034 |
[6] | YIN Zihong, ZHU Renzheng, QIU Hongtao, WANG Qingsong. Spatial Distribution Characteristics of Dynamic Displacement of Heavy-Haul Railway Subgrade System under Launching Impact Load[J]. Journal of Southwest Jiaotong University, 2021, 56(4): 777-784. doi: 10.3969/j.issn.0258-2724.20191106 |
[7] | WANG Yang, WANG Liangkun, SHI Weixing, LIU Chengqing. Performance and Application of Adjustable Height Support[J]. Journal of Southwest Jiaotong University, 2020, 55(3): 525-530. doi: 10.3969/j.issn.0258-2724.20180391 |
[8] | ZHAO Jizhong, XU Xiang, DING Li, KAN Qianhua, KANG Guozheng. Finite Element Analysis of Rolling Strengthening Process for Wheel Tread of High-Speed Trains[J]. Journal of Southwest Jiaotong University, 2020, 55(6): 1337-1347. doi: 10.3969/j.issn.0258-2724.20180803 |
[9] | LI Huadong, ZUO Mingyu, LI Pu, ZHAO Jinheng. Dynamic Response Analysis of Passive Flexible Protection System under Impact of Rockfalls[J]. Journal of Southwest Jiaotong University, 2020, 55(6): 1297-1305. doi: 10.3969/j.issn.0258-2724.20190514 |
[10] | WANG Luming, LIU Yanhui, ZHU Wenkai, HE Tingjun, KANG Xiangjie. Damage Assessment Method for Concrete-Filled Steel Tubular Columns under Impact Loading[J]. Journal of Southwest Jiaotong University, 2020, 55(4): 796-803, 819. doi: 10.3969/j.issn.0258-2724.20181037 |
[11] | YANG Qian, YANG Qinghua, ZHENG Lining, TIAN Qiang, LIU Yongquan, YAO Jintao, MU Yi, YAO Yuan. Experimental Study on Discharge and Energy Dissipation of Baffle-Drop Shaft in Deep Tunnel Drainage System[J]. Journal of Southwest Jiaotong University, 2020, 55(6): 1247-1256. doi: 10.3969/j.issn.0258-2724.20190324 |
[12] | GONG Wei, QIAO Hongxia, YU Hongfa, MA Haiyan, CHEN Guangfeng. Influence of Multiple Factors on Compressive Strength of Magnesium Oxychloride Cement Concrete[J]. Journal of Southwest Jiaotong University, 2019, 54(2): 366-372. doi: 10.3969/j.issn.0258-2724.20180042 |
[13] | ZHANG Junru, WEN Yumin, OU Xiaoqiang. Evolutionary Characteristics of Pore Structure of Fly Ash Shotcrete[J]. Journal of Southwest Jiaotong University, 2018, 53(2): 296-302. doi: 10.3969/j.issn.0258-2724.2018.02.011 |
[14] | WANG Dongpo, LIU Yang, PEI Xiangjun, SHI Si. Elasto-Plastic Dynamic Responses of Reinforced Concrete Slabs under Rockfall Impact[J]. Journal of Southwest Jiaotong University, 2016, 29(6): 1147-1153. doi: 10.3969/j.issn.0258-2724.2016.06.014 |
[15] | LIU Xinpeng, LI Zhengliang, CHEN Junfan, YAN Zhitao. Full Aeroelastic Model Design and Modal Parameter Identification of MAN Type Dry Gas Tank[J]. Journal of Southwest Jiaotong University, 2016, 29(6): 1183-1189. doi: 10.3969/j.issn.0258-2724.2016.06.019 |
[16] | DONG Tianwen, ZHENG Yingren, TANG Xiaosong. Cusp Point Condition for Estimating Ultimate Load of Pile Foundation Based on Strength Reduction Method[J]. Journal of Southwest Jiaotong University, 2014, 27(3): 373-378. doi: 10.3969/j.issn.0258-2724.2014.03.001 |
[17] | WANG Zhen, LI Guhua, ZHANG Zejiang, HUANG Tao. Effect of Fire Fighting Water on Compressive Strength of Concrete in Tunnel Fire[J]. Journal of Southwest Jiaotong University, 2011, 24(2): 223-227. doi: 10.3969/j.issn.0258-2724.2011.02.008 |
[18] | ZHANG Jun-yun, ZHOU De-pei. Experimental Study on Erosion Stability of Thick Layer Base Material Spraying Bio-Slope-Engineering[J]. Journal of Southwest Jiaotong University, 2002, 15(6): 628-631. |