应急机场土质道面疲劳变形特性模型试验
doi: 10.3969/j.issn.0258-2724.2014.03.007
Model Experiment of Fatigue Deformation Characteristic of Emergency Soil Airfield Pavement
-
摘要: 为分析应急机场快速修建工程的合理道面结构形式,采用人工加载和道面电液伺服疲劳试验机加载2种方式,对由压实土基、稳定土基层(底基层)和功能性面层组成的典型道面结构疲劳变形特性进行了模型试验.研究了土质道面结构的累积塑性变形、回弹弯沉和弯沉盆曲线随飞机荷载、施加荷载频率和荷载作用次数的变化情况及其平面分布规律.试验结果表明:累积塑性变形随加载频率增大而增大,累积塑性变形与加载次数呈对数关系;弯沉盆曲线形状类似“S”型曲线,可采用四次曲线方程进行拟合;道面结构的早期整体回弹模量增长较快,7~60 d龄期内整体回弹模量可达200~500 MPa,在数万次通行次数下,土质道面的回弹弯沉小于1 mm,表明提出的土质道面结构形式能够满足应急机场强时效性的要求.Abstract: To investigate the reasonable pavement structure for rapid construction of emergency airfield, fatigue deformation characteristics of soil airfield pavement were researched respectively by manual loading method and electro-hydraulic servo fatigue testing machine. Through a full-scale model test, the variations of cumulative plastic deformation, rebound deflection and deflection basin curve with load, loading frequency and loading times were discussed. The test results show that cumulative plastic deformation increases with loading frequency, and there exists a logarithmic relationship between it and loading times, the deflection basin curve has approximately an S-style curve and can be fitted well by a quartic polynomial equation. The carrying capacity of pavement structure increases fast at an early stage, holistic elastic modulus runs up to from 200 to 500 MPa in 7 to 60 d, the rebound deflections are less than 1 mm under ten thousands traffic times. The fatigue deformation characteristics of the recommended airfield pavement structure composed of compacted subsoil, cement stabilized soil base (or subbase) and functional surface course, can meet the requirements of emergency airfield.
-
史保华, 宁文溥, 许巍, 等. 抗耐土壤稳定剂在简易机场道面中的应用[J]. 交通运输工程学报, 2013, 13(2): 11-14. SHI Baohua, NING Wenpu, XU Wei, et al. Application of con-aid soil stabilizer in expedient airfield pavement[J]. Journal of Traffic and Transportation Engineering, 2013, 13(2): 11-14. 郝伟, 蔡良才, 王振辉, 等. 应急起降跑道复合式道面结构设计与施工技术研究[J]. 施工技术, 2008, 37(7): 30-32. HAO Wei, CAI Liangcai, WANG Zhenhui, et al. Research on design and construction technology of composite pavement structure in emergency operating runway[J]. Construction Technology, 2008, 37(7): 30-32. 谭滔, 蔡良才, 刘晓军, 等. 简易机场土质跑道设计方法[J]. 空军工程大学学报:自然科学版, 2012, 13(6): 11-14. TAN Tao, CAI Liangcai, LIU Xiaojun, et al. Research on design method of soil expedient airfield runway[J]. Journal of Air Force Engineering University: Natural Science Edition, 2012, 13(6): 11-14. 朱维光. 固化剂稳定土在应急起降跑道基层中的应用研究[D]. 西安:空军工程大学工程学院, 2010. 翁兴中, 吴彰春, 冷培义, 等. 水泥混凝土板与基础共同作用的疲劳特性[J]. 土木工程学报, 1996, 29(3): 43-48. WENG Xingzhong, WU Zhangchun, LENG Peiyi, et al. Fatigue strength of cement concrete plate on foundation[J]. China Civil Engineering Journal, 1996, 29(3): 43-48. 刘振新. 混凝土碎石化沥青加铺层路面结构模型试验[D]. 成都:西南交通大学土木工程学院, 2011. 李进军, 黄茂松, 王育德. 交通荷载作用下软土地基累积塑性变形分析[J]. 中国公路学报, 2006, 19(1): 1-5. LI Jinjun, HUANG Maosong, WANG Yude. Analysis of cumulative plastic deformation of soft clay foundation under traffic loading[J]. China Journal of Highway and Transport, 2006, 19(1): 1-5. 中华人民共和国交通运输部. JTG E51—2009公路工程无机结合料稳定材料试验规程[S]. 北京:人民交通出版社, 2009. 卢正. 交通荷载作用下公路结构动力响应及路基动强度设计方法研究[D]. 武汉:中国科学院研究生院, 2009. 李章锋. 磷石膏改良土用作路基及基层填料的试验研究[D]. 成都:西南交通大学土木工程学院, 2007. 赵明华, 陈炳初, 黄立葵. 土工格室低路堤-刚性路面结构体系模型试验[J]. 中国公路学报, 2011, 24(4): 1-6. ZHAO Minghua, CHEN Bingchu, HUANG Likui. Model test of geocell reinforced low embankment and rigid pavement system[J]. Journal of Highway and Transport, 2011, 24(4): 1-6. 中华人民共和国交通运输部. JTG E60-2008公路路基路面现场测试规程[S]. 北京:人民交通出版社, 2008. 许巍, 岑国平, 戴经梁. 简易机场道面结构的疲劳特性试验[J]. 交通运输工程学报, 2008, 8(6): 40-43. XU Wei, CEN Guoping, DAI Jingliang. Fatigue characteristic experiments of field airfield pavement structure[J]. Journal of Traffic and Transportation Engineering, 2008, 8(6): 40-43. 邹静蓉, 李志勇, 曹新文. 全风化花岗岩路基路面结构动力特性模型试验研究[J]. 公路交通科技, 2007, 24(4): 58-62. ZOU Jingrong, LI Zhiyong, CAO Xinwen. Research of the dynamic performance of the full weathering granite subgrade and pavement by model test[J]. Journal of Highway and Transportation Research and Develop-ment, 2007, 24(4): 58-62. 杜顺成, 戴经梁. 沥青混合料永久变形评价指标[J]. 中国公路学报, 2006, 19(5): 18-22. DU Shuncheng, DAI Jingliang. Permanent deformation evaluation index of asphalt mixture[J]. China Journal of Highway and Transport, 2006, 19(5): 18-22. 王旭东, 郭大进, 邓学钧. 动态弯沉盆几何特性分析[J]. 东南大学学报, 1999, 29(5): 115-120. WANG Xudong, GUO Dajin, DENG Xuejun. Geometric characteristic analysis of the dynamic deflection basin[J]. Journal of Southeast University, 1999, 29(5): 115-120.
点击查看大图
计量
- 文章访问数: 851
- HTML全文浏览量: 53
- PDF下载量: 459
- 被引次数: 0