几何参数设计对相邻电容传感器性能的影响

李楠; 韩颖

doi:10.3969/j.issn.0258-2724.2014.02.022

几何参数设计对相邻电容传感器性能的影响

doi: 10.3969/j.issn.0258-2724.2014.02.022

李楠¹,
韩颖²

基金项目:

国家自然科学基金资助项目（51105008）

北京市教委科研计划资助项目（KM201310005034）

浙江省重中之重学科开放基金

详细信息

作者简介:
李楠（1983-），讲师，博士，研究方向为无损检测、电容层析成像技术，E-mail：nan.li@hotmail.co.uk

计量
- 文章访问数: 974
- HTML全文浏览量: 71
- PDF下载量: 422
- 被引次数: 0
出版历程
- 收稿日期: 2012-05-30
- 刊出日期: 2014-03-25

Influence of Geometric Parameter Design on Performance of Capacitive Proximity Sensors

LI Nan¹,
HAN Ying²

摘要

摘要: 针对相邻电容传感器存在的测量信号微弱的问题，研究了相邻电容传感器的几何参数设计对传感器性能的具体影响，并通过几何参数的优化大幅度提高传感器测量性能.提出包括穿透深度、信号强度与噪声抑制、测量灵敏度与动态测量范围的相邻电容传感器性能综合评价细则.针对环形相邻电容传感器进行了极板几何面积变化对传感器性能影响的研究分析；设计了矩形、环形、交叉指形和螺旋盘形4种结构的相邻电容传感器，在等参数同测量环境下，对各相邻电容传感器分别进行电场仿真和边缘电容测量值比较，确定传感器几何形状对传感器性能的具体影响.实验结果表明，相邻电容传感器几何参数对传感器测量信号强度与测量灵敏度影响明显，复杂交叉指形与螺旋盘形的电容传感器测量区域的总体测量灵敏度比单结构的环形、矩形传感器的分别提高了66.8%与33.5%.
- 相邻电容传感器 /
- 信号强度 /
- 测量灵敏度 /
- 几何参数
Abstract: To deal with the weak signal strength in the measurement of capacitive proximity sensors, the effects of geometric parameter design were investigated, and the sensor measurement performance was greatly improved by the geometric parameter optimization. The comprehensive evaluation standards of sensor performance were presented, including penetration depth, signal strength and noise tolerance, measurement sensitivity and dynamic range. For round capacitive proximity sensors, the effects of the surface area on sensor performance were analyzed. Four different structures including rectangular, round, interdigital and spiral-shaped sensors were designed. In the same conditions, the electric field distributions of the sensors with four structures were simulated and the measured fringe capacitance was compared. The results indicate that the geometric parameters have remarkable influence on the measured signal strength and measurement sensitivity; comparing with rectangular and round sensors, the measurement sensitivity of interdigital and spiral-shaped sesnros was increased by 66.8% and 33.5%.
- capacitive proximity sensor /
- signal strength /
- measurement sensitivity /
- geometric parameter

HTML全文

参考文献(16)

DEMOMENT G. Image reconstruction and restoration-overview of common estimation structures and problems[J]. IEEE Trans. Acoust. Speech Signal Process., 1989, 37(12): 2024-2036.

SHRAUSS V, KALPINSH A, LOMANOVSKIS V, et al. Tomographic imaging by electrical methods[J]. Latvian Journal of Physics and Technical Sciences, 1995, 6(3): 23-47.

CHEN Zhenhai, LUO R C. Design and implementation of capacitive proximity sensor using micro-electromechanical systems technology[J]. IEEE Transactions on Industrial Electronics, 1998, 45(6): 886-894.

李喜武, 苏建, 刘玉梅. 介电常数法监测汽车发动机润滑油技术[J]. 西南交通大学学报, 2011, 46(5): 831-835. LI Xiwu, SU Jian, LIU Yumei. Technology for monitoring automotive engine lubricating oil by dielectric constant method[J]. Journal of Southwest Jiaotong University, 2011, 46(5): 831-835.

李楠, 郭宝龙, 王湃. 车辆自动雨刷系统中的传感器设计[J]. 机械工程学报, 2010, 46(14): 12-17. LI Nan, GUO Baolong, WANG Pai. Proximity capacitive sensor design in an automatic car wiper control system[J]. Journal of Mechanical Engineering, 2010, 46(14): 12-17.

李楠, 黄川, 郭宝龙. 应用于液体安全性检测的电容层析传感器设计[J]. 西安电子科技大学学报, 2010, 37(1): 125-129, 157. LI Nan, HUANG Chuan, GUO Baolong. Electrical capacitance tomography sensor design for liquid properties detection[J]. Journal of Xidian University, 2010, 37(1): 125-129, 157.

THIBAULT P, DIRIBARNE P, FOURNIER T, et al. On the design of capacitive sensors using flexible electrodes for multipurpose measurements[J]. Review of Scientific Instruments, 2007, 78(4): 043903-1-043903-7.

OLMOS A M, PRIMICIA J A, MARRON J L F. Simulation design of electrical capacitance tomography sensors[J]. Science, Measurement Technology, IET, 2007, 1(4): 216-223.

MAMISHEV A V, LESIEUTRE B C, ZAHN M. Parameter estimation using an interdigital dielectrometry sensor with finite-element software//IEEE Conference on Electrical Insulation and Dielectric Phenomena. Minneapolis.: IEEE, 1997: 234-237.

MAMISHEV A V, DU Y, BAU J H, et al. Evaluation of diffusion-driven material property profiles using three-wavelength interdigital sensor[J]. IEEE Trans. on Dielectrics and Electrical Insulation, 2001, 8(5): 785-798.

XIE C G, STOTT A L, PLASKOWSKI A, et al. Design of capacitance electrodes for concentration measurement of two-phase flow[J]. Journal of Measurement Science and Technology, 1990, 1(1): 65-78.

OLMOS A M, PRIMICIA J A, MARRON J L F. Influence of shielding arrangement on ECT sensors[J]. Sensors, 2006, 6(9): 1118-1127.

PALLAS-ARENY R, WEBSTER J G. Sensors and signal conditioning[M]. 2nd ed. New York: John Wiley Sons, 2006: 292-294.

PENG Lihui, YE Jiamin, LU Geng, et al. Evaluation of effect of number of electrodes in ECT sensors on image quality[J]. IEEE Sensors Journal, 2012, 12(5): 1554-1565.

WEBSTER J G. The measurement, instrumentation and sensors handbooks[M].: The CRC Press, IEEE Press, 1999: 8-13.

WANGSNESS R K. Electromagnetic fields[M]. 2nd ed.: Wiley, 1979: 353-358.

施引文献

附加材料(0)

访问统计